Flow of perfluorohexane in the entry region of a uniformly heated horizontal cylindrical duct was studied in a regime of weakly turbulent mixed convection. Heat transfer coefficients were measured at five cross sections along the heated length and various values of flow rate and heat flux were imposed. A different thermofluid-dynamic behavior was observed between the upper and lower sides of the pipe. Correlations of the Nusselt number for developed and developing flow were proposed, showing agreement with the experimental data within the 10% deviation band.

1.

Polyakov

, A. F.

, 1997, “Mixed (Combined) Convection

,” International Encyclopedia of Heat and Mass Transfer

, G. F.

Hewitt

, G. L.

Shires

, and Y. V.

Polezhaev

, eds., CRC Press LLC

, Boca Raton, FL

, pp. 725

–727

.2.

Metais

, B.

, 1963, “Criteria for Mixed Convection

,” Technical Report No. 51, Heat Transfer Laboratory

, University of Minnesota, Minneapolis, MN.3.

Metais

, B.

, and Eckert

, E. R. G.

, 1964, “Forced, Mixed, and Free Convection Regimes

,” J. Heat Transfer

0022-1481, 86

, pp. 295

–296

.4.

Kakaç

, S.

, Shah

, R. K.

, and Aung

, W.

, 1987, Handbook of Single-Phase Convective Heat Transfer

, Wiley

, New York

, Chap. 15.5.

Petukhov

, B. S.

, and Polyakov

, A. F.

, 1988, Heat Transfer in Turbulent Mixed Convection

, Hemisphere Publishing Corporation

, New York

, Chap. 3, 5.6.

Mori

, Y.

, Futagami

, K.

, Tokuda

, S.

, and Nakamura

, M.

, 1966, “Forced Convective Heat Transfer in Uniformly Heated Horizontal Tubes, 1st Report—Experimental Study on the Effect of Buoyancy

,” Int. J. Heat Mass Transfer

0017-9310, 9

, pp. 453

–463

.7.

Mori

, Y.

, and Futagami

, K.

, 1967, “Forced Convective Heat Transfer in Uniformly Heated Horizontal Tubes (2nd Report, Theoretical Study)

,” Int. J. Heat Mass Transfer

0017-9310, 10

, pp. 1801

–1813

.8.

Faris

, G. N.

, and Viskanta

, R.

, 1969, “An Analysis of Laminar Combined Forced and Free Convection Heat Transfer in a Horizontal Tube

,” Int. J. Heat Mass Transfer

0017-9310, 12

, pp. 1295

–1309

.9.

Hwang

, G. J.

, and Cheng

, K. C.

, 1970, “Boundary Vorticity Method for Convective Heat Transfer with Secondary Flow-Application to the Combined Free and Forced Laminar Convection in Horizontal Tubes

,” Proc. Fourth International Heat Transfer Conf.

, Paris-Versailles, France, Vol. 4

, Paper NC3.5, pp. 1

–12

.10.

Petukhov

, B. S.

, and Polyakov

, A. F.

, 1970, “Flow and Heat Transfer in Horizontal Tubes under Combined Effect of Forced and Free Convection

,” Proc. Fourth International Heat Transfer Conf.

, Paris-Versailles, France, Vol. 4

, Paper NC3.7, pp. 1

–11

.11.

Morcos

, S. M.

, and Bergles

, A. E.

, 1975, “Experimental Investigation of Combined Forced and Free Laminar Convection in Horizontal Tubes

,” J. Heat Transfer

0022-1481, 97

, pp. 212

–219

.12.

Hattori

, N.

, and Kotake

, S.

, 1978, “Combined Free and Forced-Convection Heat-Transfer for Fully-Developed Laminar Flow in Horizontal Tubes—Experiments

,” Bull. JSME

0021-3764, 21

, pp. 861

–868

.13.

Patankar

, S. V.

, Ramadhyani

, S.

, and Sparrow

, E. M.

, 1978, “Effect of Circumferentially Nonuniform Heating on Laminar Combined Convection in a Horizontal Tube

,” J. Heat Transfer

0022-1481, 100

, pp. 63

–70

.14.

Hattori

, N.

, 1979, “Combined Free and Forced Convection Heat Transfer for Fully Developed Laminar Flow in Concentric Annuli (Numerical Analysis)

,” JSME Trans.

, 45

, pp. 227

–239

.15.

Kotake

, S.

, and Hattori

, N.

, 1985, “Combined Free and Forced Convection Heat Transfer for Fully Developed Laminar Flow in Concentric Annuli

,” Int. J. Heat Mass Transfer

0017-9310, 28

, pp. 2115

–2120

.16.

Ciampi

, M.

, Faggiani

, S.

, Grassi

, W.

, Incropera

, F. P.

, and Tuoni

, G.

, 1986, “Experimental Study of Mixed Convection in Horizontal Annuli for Low Reynolds Number

,” Proc. Eighth International Heat Transfer Conf.

, San Francisco, CA, Vol. 3

, pp. 1413

–1418

.17.

Ciampi

, M.

, Faggiani

, S.

, Grassi

, W.

, Tuoni

, G.

, and Incropera

, F. P.

, 1987, “Mixed Convection Heat-Transfer in Horizontal, Concentric Annuli for Transitional Flow Conditions

,” Int. J. Heat Mass Transfer

0017-9310, 30

, pp. 833

–841

.18.

McComas

, S. T.

, and Eckert

, E. R. G.

, 1966, “Combined Free and Forced Convection in a Horizontal Circular Tube

,” J. Heat Transfer

0022-1481, 88

, pp. 147

–153

.19.

Shannon

, R. L.

, and Depew

, C. A.

, 1968, “Combined Free and Forced Laminar Convection in a Horizontal Tube with Uniform Heat Flux

,” J. Heat Transfer

0022-1481, 90

, pp. 353

–357

.20.

Shannon

, R. L.

, and Depew

, C. A.

, 1969, “Forced Laminar Flow Convection in a Horizontal Tube with Variable Viscosity and Free-Convection Effects

,” J. Heat Transfer

0022-1481, 91

, pp. 251

–258

.21.

Depew

, C. A.

, and August

, S. E.

, 1971, “Heat Transfer due to Combined Free and Forced Convection in a Horizontal and Isothermal Tube

,” J. Heat Transfer

0022-1481, 93

, pp. 380

–384

.22.

Kamotani

, Y.

, and Ostrach

, S.

, 1976, “Effect of Thermal Instability on Thermally Developing Laminar Channel Flow

,” J. Heat Transfer

0022-1481, 98

, pp. 62

–66

.23.

Kamotani

, Y.

, Ostrach

, S.

, and Miao

, H.

, 1979, “Convective Heat Transfer Augmentation in Thermal Entrance Regions by means of Thermal Instability

,” J. Heat Transfer

0022-1481, 101

, pp. 222

–226

.24.

Yousef

, W. W.

, and Tarasuk

, J. D.

, 1982, “Free Convection Effects on Laminar Forced Convective Heat Transfer in a Horizontal Isothermal Tube

,” J. Heat Transfer

0022-1481, 104

, pp. 145

–152

.25.

Barozzi

, G. S.

, Zanchini

, E.

, and Mariotti

, M.

, 1985, “Experimental Investigation of Combined Forced and Free Convection in Horizontal and Inclined Tubes

,” Meccanica

0025-6455, 20

, pp. 18

–27

.26.

Osborne

, D. G.

, and Incropera

, F. P.

, 1985, “Laminar, Mixed Convection Heat Transfer for Flow between Horizontal Parallel Plates with Asymmetric Heating

,” Int. J. Heat Mass Transfer

0017-9310, 28

, pp. 207

–217

.27.

Incropera

, F. P.

, Knox

, A. L.

, and Maughan

, J. R.

, 1987, “Mixed-Convection Flow and Heat-Transfer in the Entry Region of a Horizontal Rectangular Duct

,” J. Heat Transfer

0022-1481, 109

, pp. 434

–439

.28.

Maughan

, J. R.

, and Incropera

, F. P.

, 1987, “Experiments on Mixed Convection Heat Transfer for Airflow in a Horizontal and Inclined Channel

,” Int. J. Heat Mass Transfer

0017-9310, 30

, pp. 1307

–1318

.29.

Maughan

, J. R.

, and Incropera

, F. P.

, 1990, “Regions of Heat Transfer Enhancement for Laminar Mixed Convection in a Parallel Plate Channel

,” Int. J. Heat Mass Transfer

0017-9310, 33

, pp. 555

–570

.30.

Lei

, Q. M.

, and Trupp

, A. C.

, 1991, “Experimental Study of Laminar Mixed Convection in the Entrance Region of a Horizontal Semicircular Duct

,” Int. J. Heat Mass Transfer

0017-9310, 34

, pp. 2361

–2372

.31.

Zhang

, C.

, and Bell

, K. J.

, 1992, “Mixed Convection inside Horizontal Tubes with Nominally Uniform Heat Flux

,” AIChE Symp. Ser.

0065-8812, 88

, pp. 212

–219

.32.

Choi

, D. K.

, and Choi

, D. H.

, 1994, “Developing Mixed Convection Flow in a Horizontal Tube under Circumferentially Non-Uniform Heating

,” Int. J. Heat Mass Transfer

0017-9310, 37

, pp. 1899

–1913

.33.

Wang

, M.

, Tsuji

, T.

, and Nagano

, Y.

, 1994, “Mixed Convection with Flow Reversal in the Thermal Entrance Region of Horizontal and Vertical Pipes

,” Int. J. Heat Mass Transfer

0017-9310, 37

, pp. 2305

–2319

.34.

Shome

, B.

, and Jensen

, M. K.

, 1995, “Mixed Convection Laminar Flow and Heat Transfer of Liquids in Isothermal Horizontal Circular Ducts

,” Int. J. Heat Mass Transfer

0017-9310, 38

, pp. 1945

–1956

.35.

Islam

, N.

, Gaitonde

, U. N.

, and Sharma

, G. K.

, 2001, “Mixed Convection Heat Transfer in the Entrance Region of Horizontal Annuli

,” Int. J. Heat Mass Transfer

0017-9310, 44

, pp. 2107

–2120

.36.

Hussain

, N. A.

, and McComas

, S. T.

, 1970, “Experimental Investigation of Combined Convection in a Horizontal Circular Tube with Uniform Heat Flux

,” Proc. Fourth International Heat Transfer Conf.

, Paris-Versailles, France, Vol. 4

, Paper NC3.4, pp. 1

–11

.37.

Ghajar

, A. J.

, and Tam

, L.-M.

, 1994, “Heat Transfer Measurements and Correlations in the Transition Region for a Circular Tube with Three Different Inlet Configurations

,” Exp. Therm. Fluid Sci.

0894-1777, 8

, pp. 79

–90

.38.

Ghajar

, A. J.

, and Tam

, L.-M.

, 1995, “Flow Regime Map for a Horizontal Pipe with Uniform Wall Heat Flux and Three Inlet Configurations

,” Exp. Therm. Fluid Sci.

0894-1777, 10

, pp. 287

–297

.39.

Tam

, L.-M.

, and Ghajar

, A. J.

, 1998, “The Unusual Behavior of Local Heat Transfer Coefficient in a Circular Tube with a Bell-Mouth Inlet

,” Exp. Therm. Fluid Sci.

0894-1777, 16

, pp. 187

–194

.40.

Ghajar

, A. J.

, Tam

, L.-M.

, and Tam

, S. C.

, 2004, “Improved Heat Transfer Correlation in the Transition Region for a Circular Tube with Three Inlet Configurations Using Artificial Neural Networks

,” Heat Transfer Eng.

0145-7632, 25

, pp. 30

–40

.41.

Wang

, G. S.

, Incropera

, F. P.

, and Viskanta

, R.

, 1983, “Mixed Convection Heat Transfer in a Horizontal Open-Channel Flow with Uniform Bottom Heat Flux

,” J. Heat Transfer

0022-1481, 105

, pp. 817

–822

.42.

Osborne

, D. G.

, and Incropera

, F. P.

, 1985, “Experimental Study of Mixed Convection Heat Transfer for Transitional and Turbulent Flow between Horizontal, Parallel Plates

,” Int. J. Heat Mass Transfer

0017-9310, 28

, pp. 1337

–1344

.43.

Grassi

, W.

, and Testi

, D.

, 2006, “Heat Transfer Augmentation by Ion Injection in an Annular Duct

,” J. Heat Transfer

0022-1481, 128

, pp. 283

–289

.Copyright © 2006

by American Society of Mechanical Engineers

You do not currently have access to this content.