Through a series of computational studies, carbon monoxide has been identified as an important promoter of NO oxidation to NO2 in combustion turbine exhaust gas at intermediate temperatures (450 to 750°C). NO2 formation is accompanied by enhanced CO burnout at these temperatures. Perfectly stirred reactor and plug flow reactor calculations indicate that concentrations of CO as low as 50 ppmv in exhaust gas containing 25 ppmv NO can result in the conversion of 50 percent of the NO to NO2 in less than 1 s. NO2 concentrations as low as 15 ppmv can result in visible, yellow-brown plumes from large diameter exhaust stacks. If NO2 plumes are to be prevented, then designers of gas turbines and heat recovery steam generators need to be aware of the relationships between time, temperature, and composition which cause NO2 to form in exhaust gas. Reaction path analysis indicates that the mutually promoted oxidation of CO and NO occurs through a self-propagating, three-step chain reaction mechanism. CO is oxidized by OH CO+OH→CO2+H, while NO is oxidized by HO2:NO+HO2→NO2+OH. In a narrow temperature range, the H-atom produced by the first reaction can react with O2 in a three body reaction to yield the hydroperoxy radical needed in the second reaction: H+O2+M→HO2+M, where M is any third body. The observed net reaction is CO+O2+NO→CO2+NO2, which occurs stoichiometrically at temperatures below about 550°C. As the temperature increases, additional reaction pathways become available for H, HO2, and OH which remove these radicals from the chain and eventually completely decouple the oxidation of CO from NO. An abbreviated set of elementary chemical reactions, including 15 species and 33 reactions, has been developed to model CO-enhanced oxidation of NO to NO2. This reaction set was derived from a larger reaction set with more than 50 species and 230 elementary chemical reactions, and was validated by comparison of PSR and PFR calculations using the two sets. [S0742-4795(00)01402-2]

Issue Section:
Gas Turbines: Combustion and Fuel
Keywords:
carbon compounds, nitrogen compounds, oxygen compounds, air pollution, pollution control, oxidation, combustion, internal combustion engines, gas turbines
Topics:
Carbon, Carbon dioxide, Combustion, Exhaust systems, Gas turbines, Oxidation, Plumes (Fluid dynamics), Temperature, Chain, Water, Turbines, Pressure, Atoms, Flow (Dynamics)
1.
Sano
,
T.
,
1985
,
Combust. Sci. Technol.
,
38
, pp.
129
–
144
.
2.
Corr, R. A., 1995, personal communication.
3.
Jaasma
,
D.
, and
Borman
,
G.
,
1980
,
Combust. Sci. Technol.
,
23
, p.
83
83
.
4.
Bromly
,
J. H.
,
Barnes
,
F. J.
, and
Little
,
L. H.
,
1988
,
J. Inst. Energy
,
61
, p.
89
89
.
5.
Bromly, J. H., Barnes, F. J., Mandyczewsky, R., Edwards, T. J., and Haynes, B. S., 1992, Twenty-Fourth Symposium (International) on Combustion, The Combustion Institute, Pittsburgh, PA, pp. 899–907.
6.
Hori, M., Matsunaga, N., Malte, P. C., and Marinov, N. M., 1992, Twenty Fourth Symposium (International) on Combustion, The Combustion Institute, Pittsburgh, PA, pp. 909–916.
7.
Glarborg
,
P.
,
Kubel
,
D.
,
Kristensen
,
P. G.
,
Hansen
,
J.
, and
DamJohansen
,
K.
,
1995
,
Combust. Sci. Technol.
,
110–111
, pp.
461
–
485
.
8.
Miller
,
J. A.
, and
Bowman
,
C. T.
,
1989
,
Prog. Energy Combust. Sci.
,
15
, pp.
287
–
338
.
9.
Glarborg, P., Kee, R. J., Grcar, J. F., and Miller, J. A., 1986, “PSR: A FORTRAN Program for Modeling Well-Stirred Reactors,” Sandia National Laboratories Report SAND86-8209.
10.
Bowman, C. T., Hanson, R. K., Davidson, D. F., Gardiner, Jr., W. C., Lissianski, V., Smith, G. P., Golden, D. M., Frenklach, M., and Goldenberg, M., http://www.me.berkeley.edu/gri_mech/.
11.
Melo
,
O. T.
, and
Stevens
,
R. D. S.
,
1981
,
Atmos. Environ.
,
15
, p.
12
12
.
12.
Kee, R. J., Rupley, F. M., and Miller, J. A., 1989, “Chemkin-II: A Fortran Chemical Kinetics Package for the Analysis of Gas-Phase Chemical Kinetics,” Sandia National Laboratories, Report SAND89-8009.
13.
Lutz, A. E., Kee, R. J., and Miller, J. A., 1988, “SENKIN: A Fortran Program for Predicting Homogeneous Gas Phase Chemical Kinetics with Sensitivity Analysis,” Sandia National Laboratories, Report SAND87-8248.
14.
Michaud, M. G., Westmoreland, P. R., and Feitelberg, A. S., 1992, Twenty-Fourth Symposium (International) on Combustion, The Combustion Institute, Pittsburgh, PA, pp. 879–887.
15.
Mallard, W. G., Westley, F., Herron, J. T., and Hampson, R. F., 1992, “NIST Chemical Kinetics Database-Ver. 4.0,” NIST Standard Reference Data, Gaithersburg, MD.
Copyright © 2000
 by ASME
You do not currently have access to this content.